Influence of Cold Maceration Time on Chromatic and Microbiological Characteristics of Cabernet Sauvignon Wines

  • B. Kuchen Instituto de Biotecnología, Facultad de Ingeniería - Universidad Nacional de San Juan Consejo Nacional de Investigaciones Científicas y Técnicas - CONICET
  • F. Vazquez Instituto de Biotecnología, Facultad de Ingeniería - Universidad Nacional de San Juan
  • M.V. Mestre Instituto de Biotecnología, Facultad de Ingeniería - Universidad Nacional de San Juan Consejo Nacional de Investigaciones Científicas y Técnicas - CONICET
  • M.E. Toro Instituto de Biotecnología, Facultad de Ingeniería - Universidad Nacional de San Juan
  • Y.P. Maturano Instituto de Biotecnología, Facultad de Ingeniería - Universidad Nacional de San Juan Consejo Nacional de Investigaciones Científicas y Técnicas - CONICET

Abstract

The pre-fermentative cold soak (CS) is proposed so as to extract and stabilise polyphenolic compounds in wines. CS is applied empirically to Cabernet Sauvignon in Cuyo, Argentina; however, there is poor scientific background on this technique. The aim was analyse the effect of cold soak time on colour parameters such as total polyphenols, total anthocyanins, tannins, colour and polymerisation indexes.  Moreover, Saccharomyces and non-Saccharomyces populations were studied to evaluate their impact on
colour. Cabernet Sauvignon must (Pedernal, San Juan) was distributed into four vessels: CONTROL (CT): simultaneous maceration and alcoholic fermentation (AF) with commercial yeast D254; T1: CS for two days; T2: CS for five days; and T3: CS for seven days. T1, T2 and T3 were maintained at 4 ± 1°C during CS.  They were later inoculated with D254 (AF: 22 ± 1°C). The total polyphenol index (TPI), total anthocyanins (TA) and tannins were quantified during CS and AF. The colour index (CI) and polymerisation index (PI) were determined at the end of AF. The total yeast populations of Saccharomyces and non-Saccharomyces were quantified during CS and AF. The highest values of TA, tannins, TPI and PI were obtained by CT.
This treatment also registered the highest total yeast population and the highest total yeast death. The highest CI was observed in T3. When Saccharomyces was found at the end of CS (T1 and T2), it dominated
the alcoholic fermentation in the early stages (not observed in CT and T3). The use of the pre-fermentative CS technique in Cabernet Sauvignon wines is promising for young wines due to the increased colour obtained.

Downloads

Download data is not yet available.

References

Alañón, M. E., Schumacher, R., Díaz-Maroto, M. C., Hermosín-Gutiérrez, I., Bettoni, J. C., Gardin, J. P. & Pérez-Coello, M. S. 2016. By-products of pyro-bituminous shale as amendments in Brazilian vineyards: Influence on polyphenolic composition of Cabernet Sauvignon wines. Food Research International, 81, 122-132.

Albertin, W., Miot-Sertier, C., Bely, M., Marullo, P., Coulon, J., Moine, V., Colonna-Ceccaldi, B. & Masneuf-Pomarede, I. 2014. Oenological prefermentation practices strongly impact yeast population dynamics and alcoholic fermentation kinetics in Chardonnay grape must. International journal of food microbiology, 178, 87-97.

Alexandre, H. and Guilloux-Benatier, M. 2006. Yeast autolysis in sparkling wine–a review. Aus. J. Grape & Wine Res. 12:119-127.

Álvarez, I., Aleixandre, J. L., García, M. J. & Lizama, V. 2006. Impact of prefermentative maceration on the phenolic and volatile compounds in Monastrell red wines. Analytica Chimica Acta, 563(1), 109-115.

Amrani Joutei, K. & Glories, Y. 1994. Etude en conditions modèles de l'extractibillté des composés phénoliques des pellicules et des pépins de raisins rouges. J. Int. Sci. Vigne et du Vin. 28(4), 303-317.

Asenstorfer, R.E., Markides A. J., Iland, P. G. and Jones, G. P. 2003. Formation of vitisin A during red wine fermentation and maturation. Aus. J. Grape & Wine Res. 9:40-46.

Baiano, A., Scrocco, C., Sepielli, G. & Del Nobile, M. A. 2016. Wine Processing: A Critical Review of Physical, Chemical, and Sensory Implications of Innovative Vinification Procedures. Critical reviews in food science and nutrition, 56(14), 2391-2407.

Barrajón, N., Arévalo-Villena, M., Úbeda, J. & Briones, A. 2011. Enological properties in wild and commercial Saccharomyces cerevisiae yeasts: relationship with competition during alcoholic fermentation. World Journal of Microbiology and Biotechnology, 27(11), 2703-2710.

Beltran, G., Novo, M., Guillamón, J. M., Mas, A. & Rozès, N. 2008. Effect of fermentation temperature and culture media on the yeast lipid composition and wine volatile compounds. International journal of food microbiology, 121(2), 169-177.

Boulton, R. 2001. The copigmentation of anthocyanins and its role in the colour of red wine: a critical review. Am. J. Enol. Vitic. 52:67-87.

Brouillard, R. 1982. Chemical structure of anthocyanins. Academic Press: New York.

Casassa, L. F. 2007. Efecto de dos variantes de maceración prefermentativa en frio (MPF) sobre la composición y características organolépticas de vinos Malbec. Tesis, Universidad Nacional de Cuyo.

Casassa, F., Sari, S., Avagnina, S., Días, M., Jofré, V., Fanzone, M. & Catania, C. 2007. Influencia de dos técnicas de maceración sobre la composición polifenolica, aromática y las características organolépticas de vinos cv. Merlot. Viticultura & Enología Profesional, 109: 5-20.

Casassa, L.F., E.A. Bolcato & Sari S. E.. 2015. Chemical, chromatic, and sensory attributes of 6 red wines produced with prefermentative cold soak. Food Chem. 174:110-118.

Cavalcanti, R.N., Santos, D. T. & Meireles, M. A. A. 2011. Non-thermal stabilization mechanisms of anthocyanins in model and food systems—An overview. Food Res. Int. 44:499-509.

Chalier, P., Angot, B., Delteil, D., Doco, T. & Gunata, Z. 2007. Interactions between aroma compounds and whole mannoprotein isolated from Saccharomyces cerevisiae strains. Food chemistry, 100(1), 22-30.

Charoenchai, C., Fleet, G., Henschke, P. & Todd, B. 1997. Screening of non‐Saccharomyces wine yeasts for the presence of extracellular hydrolytic enzymes. Aus. J. Grape & Wine Res. 3:2-8.

Cheynier, V., Dueñas-Paton, M., Salas, E., Maury, C., Souquet, J. M., Sarni-Manchado, P. & Fulcrand, H. 2006. Structure and properties of wine pigments and tannins. American Journal of Enology and Viticulture, 57(3), 298-305.

De Beer, D., Joubert, E., Marais, J., & Manley, M. 2017. Maceration before and during fermentation: Effect on Pinotage wine phenolic composition, total antioxidant capacity and objective colour parameters. South African Journal of Enology and Viticulture, 27(2), 137-150.

Domizio, P., Romani, C., Lencioni, L., Comitini, F., Gobbi, M., Mannazzu, I. & Ciani, M. 2011. Outlining a future for non-Saccharomyces yeasts: selection of putative spoilage wine strains to be used in association with Saccharomyces cerevisiae for grape juice fermentation. International journal of food microbiology, 147(3), 170-180.

Domizio, P., Liu, Y., Bisson, L. F. & Barile, D. 2014. Use of non-Saccharomyces wine yeasts as novel sources of mannoproteins in wine. Food microbiology, 43, 5-15.

Eglinton, J., Griesser, M., Henschke, P., Kwiatkowski, M., Parker, M. & Herderich, M. 2004. Yeast-mediated formation of pigmented polymers in red wine. In ACS Symposium series. Anonymous , pp. 7-21. Oxford University Press.

Escribano-Bailón, T., Álvarez-García, M., Rivas-Gonzalo, J. C., Heredia, F. J. & Santos-Buelga, C. 2001. Colour and stability of pigments derived from the acetaldehyde-mediated condensation between malvidin 3-O-glucoside and (+)-catechin. Journal of Agricultural and Food Chemistry, 49(3), 1213-1217.

Fernández, M., Ubeda, J. F. & Briones, A. I. 2000. Typing of non-Saccharomyces yeasts with enzymatic activities of interest in wine-making. International journal of food microbiology, 59(1), 29-36.

Fleet, G.H. 2003. Yeast interactions and wine flavour. Int. J. Food Microbiol. 86:11-22.

Fowell, R. 1965. The identification of wild yeast colonies on lysine agar. J. Appl. Bacteriol. 28:373-383.

Fugelsang, K.C. & Edwards C. G. 2006. Wine microbiology: practical applications and procedures. Springer Sci. & Business Media.

Gauche, C., Malagoli, E. D. S. & Bordignon Luiz, M. T. 2010. Effect of pH on the copigmentation of anthocyanins from Cabernet Sauvignon grape extracts with organic acids. Scientia Agricola, 67(1), 41-46.

Giovani, G., Rosi, I. & Bertuccioli, M. 2012. Quantification and characterization of cell wall polysaccharides released by non-Saccharomyces yeast strains during alcoholic fermentation. International journal of food microbiology, 160(2), 113-118.

Glories, Y. 1984. La couleur des vins rouges: 2e. Partie: mesure, origine et interpretation. Connaissance de la Vigne et du Vin. 18.

Gómez-Míguez, M., González-Miret, M. L. & Heredia, F. J. 2007. Evolution of colour and anthocyanin composition of Syrah wines elaborated with pre-fermentative cold maceration. Journal of Food Engineering, 79(1), 271-278.

González‐Neves, G., Gil, G., Favre, G. & Ferrer, M. 2012. Influence of grape composition and winemaking on the anthocyanin composition of red wines of Tannat. International journal of food science & technology, 47(5), 900-909.

Gonzalez-San Jose, M. L., Santa-Maria, G. & Diez, C. 1990. Anthocyanins as parameters for differentiating wines by grape variety, wine-growing region, and wine-making methods. Journal of food composition and analysis, 3(1), 54-66.

Granchi, L., Ganucci, D., Messini, A. & Vincenzini, M. 2002. Oenological properties of Hanseniaspora osmophila and Kloeckera corticis from wines produced by spontaneous fermentations of normal and dried grapes. FEMS yeast research, 2(3), 403-407.

Heredia, F. J., Escudero-Gilete, M. L., Hernanz, D., Gordillo, B., Meléndez-Martínez, A. J., Vicario, I. M. & González-Miret, M. L. 2010. Influence of the refrigeration technique on the colour and phenolic composition of Syrah red wines obtained by pre-fermentative cold maceration. Food Chemistry, 118(2), 377-383.

Hermosín Gutiérrez, I. 2003. Influence of ethanol content on the extent of copigmentation in a Cencibel young red wine. J. Agric. Food Chem. 51:4079-4083.

Hierro, N., González, Á., Mas, A. & Guillamón, J. M. 2005. Diversity and evolution of non-Saccharomyces yeast populations during wine fermentation: effect of grape ripeness and cold maceration. FEMS Yeast Research, 6(1), 102-111.

Iland, P., Bruer, N., Edwards, G., Weeks, S. & Wilkes, E.. 2004. Chemical analysis of grapes and wine: techniques and concepts (Patrick Iland Wine Promotions: Campbelltown).

Jackson, R. S. 2014. Wine Science (Fourth Edition). Food Science and Technology pp.:347-426. Academic Press.

Kammerer, D. R. 2016. Handbook on Natural Pigments in Food and Beverages. Elsevier, Amsterdam.

Kurtzman, C., Fell, J. W. & Boekhout T. (Eds.). 2011. The yeasts: a taxonomic study.

Liu, G. L., Chi, Z., Wang, G. Y., Wang, Z. P., Li, Y. & Chi, Z. M. 2015. Yeast killer toxins, molecular mechanisms of their action and their applications. Critical reviews in biotechnology, 35(2), 222-234.

Liu, P. T., Lu, L., Duan, C. Q. & Yan, G. L. 2016. The contribution of indigenous non-Saccharomyces wine yeast to improved aromatic quality of Cabernet Sauvignon wines by spontaneous fermentation. LWT-Food Science and Technology, 71, 356-363.

Mangani, S., Buscioni, G., Collina, L., Bocci, E. & Vincenzini, M. 2011. Effects of microbial populations on anthocyanin profile of Sangiovese wines produced in Tuscany, Italy. American journal of enology and viticulture: ajev. 2011.11047

Manzanares, P., Rojas, V., Genovés, S. & Vallés, S. 2000. A preliminary search for anthocyanin‐β‐D‐glucosidase activity in non‐Saccharomyces wine yeasts. International journal of food science & technology, 35(1), 95-103.

Marais, J., 2003. Effect of different wine-making techniques on the composition and quality of Pinotage wine - I: low-temperature skin contact prior to fermentation. S. Afr. J. Enol. Vitic. 24, 70–75.

Mateo, J. & Di Stefano, R. 1997. Description of theβ-glucosidase activity of wine yeasts. Food Microbiol. 14:583-591.

Maturano, Y. P., Assaf, L. A. R., Toro, M. E., Nally, M. C., Vallejo, M., Castellanos de Figueroa, L. I., Combina, M. & Vazquez, F. 2012. Multi-enzyme production by pure and mixed cultures of Saccharomyces and non-Saccharomyces yeasts during wine fermentation. International journal of food microbiology, 155(1), 43-50.

Maturano, Y. P., Mestre, M. V., Esteve-Zarzoso, B., Nally, M. C., Lerena, M. C., Toro, M. E., Vazquez, F. & Combina, M. 2015. Yeast population dynamics during prefermentative cold soak of Cabernet Sauvignon and Malbec wines. International journal of food microbiology, 199, 23-32.

Mazza, G. & Brouillard, R.. 1987. Recent developments in the stabilization of anthocyanins in food products. Food Chem. 25:207-225.

Mendoza, L. M., Manca de Nadra, M. C. & Farías, M. E. 2007. Kinetics and metabolic behavior of a composite culture of Kloeckera apiculata and Saccharomyces cerevisiae wine related strains. Biotechnology letters, 29(7), 1057-1063.

Mendoza, L. M., Manca de Nadra, M. C., Bru, E. & Farías, M. E. 2009. Influence of wine-related physicochemical factors on the growth and metabolism of non-Saccharomyces and Saccharomyces yeasts in mixed culture. Journal of industrial microbiology & biotechnology, 36(2), 229-237.

Mercado, L., Dalcero, A., Masuelli, R. & Combina, M. 2007. Diversity of Saccharomyces strains on grapes and winery surfaces: analysis of their contribution to fermentative flora of Malbec wine from Mendoza (Argentina) during two consecutive years. Food microbiology, 24(4), 403-412.

Miller, G. L. 1959. Use of Dinitrosalicylic Acid Reagent for Determination of Reducing Sugar. Analytical chemistry, 31(3), 426-428.

Moncada, X., Pelsy, F., Merdinoglu, D. & Hinrichsen, P. 2006. Genetic diversity and geographical dispersal in grapevine clones revealed by microsatellite markers. Genome, 49(11), 1459-1472.

Morata, A., Gómez-Cordovés, M. C., Suberviola, J., Bartolomé, B., Colomo, B. & Suárez, J. A. 2003. Adsorption of anthocyanins by yeast cell walls during the fermentation of red wines. Journal of Agricultural and Food Chemistry, 51(14), 4084-4088.

Morata, A., Loira, I., Heras, J. M., Callejo, M. J., Tesfaye, W., González, C. & Suárez-Lepe, J. A. 2016. Yeast influence on the formation of stable pigments in red winemaking. Food chemistry, 197, 686-691.

Morel-Salmi, C., Souquet, J. M., Bes, M. & Cheynier, V. 2006. Effect of flash release treatment on phenolic extraction and wine composition. Journal of agricultural and food chemistry, 54(12), 4270-4276.

Mortimer, R. K. 2000. Evolution and variation of the yeast Saccharomyces genome. J. Genome Res. 10, 403–409.

Nazrala, J. J. B., Paladino, S. C., Vila, H. F. & Lucero, C. C. 2009. Manual de técnicas analíticas para mostos y vinos. Ed: Instituto Nacional de Tecnología Agropecuaria.

Ortega-Heras, M., Pérez-Magariño, S. & González-Sanjosé, M. L. 2012. Comparative study of the use of maceration enzymes and cold pre-fermentative maceration on phenolic and anthocyanic composition and colour of a Mencía red wine. LWT-Food Science and Technology, 48(1), 1-8.

Pelsy, F. 2010. Molecular and cellular mechanisms of diversity within grapevine varieties. Heredity, 104(4), 331-340.

Reynolds, A., Cliff, M., Girard, B. & Kopp, T. G. 2001. Influence of fermentation temperature on composition and sensory properties of Semillon and Shiraz wines. American Journal of Enology and Viticulture, 52(3), 235-240.

Ribéreau-Gayon, P. 1982. The anthocyanins of grapes and wines. Academic Press: New York.

Ribéreau-Gayon, P. 1998.Traité d'OEnologie. 2-Chimie du vin. Stabilisation et traitements. Ed. La Vigne .Paris.

Ribéreau‐Gayon, P., Glories, Y., Maujean, A. & Dubourdieu, D. 2000. Chemical nature, origins and consequences of the main organoleptic defects. Handbook of Enology: The Chemistry of Wine Stabilization and Treatments, Volume 2, 2nd Edition, 231-284.

Robinson J. 2006. The Oxford Companion to Wine (3ª edition). Oxford University Press: 119-121.

Somers, T.C. and Evans, M. E. 1974. Wine quality: Correlations with colour density and anthocyanin equilibria in a group of young red wines. J. Sci. Food & Agric. 25:1369-1379.

Somers, T.C. and Evans, M. E. 1977. Spectral evaluation of young red wines: Anthocyanin equilibria, total phenols, free and molecular SO2 and chemical age. J. Sci. Food & Agric.: 28: 279 - 287.

Strauss, M. L. A., Jolly, N. P., Lambrechts, M. G. & Van Rensburg, P. 2001. Screening for the production of extracellular hydrolytic enzymes by non‐Saccharomyces wine yeasts. Journal of applied microbiology, 91(1), 182-190.

Suárez-Lepe, J. A. and Morata, A. 2012. New trends in yeast selection for winemaking. Trends Food Sci. & Tech. 23(1), 39-50.

Sudraud, P. 1958. Interpretation des courbes d’absorption des vins rouges. Ann. Technol. Agric, 7(2), 203-208.

Vernocchi, P., Patrignani, F., Ndagijimana, M., Lopez, C. C., Suzzi, G., Gardini, F. & Lanciotti, R. 2015. Trebbiano wine produced by using Saccharomyces cerevisiae strains endowed with β-glucosidase activity. Annals of microbiology, 65(3), 1565-1571.

Vila, H. F., Paladino, S. C., Nazrala, J. J. B. & Lucero, C. C. 2009. Manual de técnicas analíticas para la evaluación de compuestos fenólicos y otros componentes de la uva. Ed: Instituto Nacional de Tecnología Agropecuaria.

Zoecklein, B. W., Gump, B., Fugelsang, K. & Nury, F. S. 1995. Wine analysis and production. Ed. Chapman and Hall, New York. 621.

Zou, H., Kilmartin, P. A., Inglis, M. J. & Frost, A.. 2002. Extraction of phenolic compounds during vinification of Pinot Noir wine examined by HPLC and cyclic voltammetry. Australian Journal of Grape and Wine Research, 8(3), 163-174.

Published
2018-05-09
Section
Articles